服装中英文疵点描述

服装QC 英语/中文

1、Appearance 外观 Dirty mark 污渍 Water spot 水斑点 water stain 水渍

Cleaning mark 枪水渍（打枪痕渍） oil stain 油渍 rust 锈迹

undesirable odor 臭味

There is dirty mark on garment 衣服上有脏迹 dirty dot （较小的）污点 dirty spot （较大的）污点

color fibre woven in 杂色纤维织入（面料上有杂色纱线） color yarn 杂色纱

mix color yarn 杂色纱织入（面料中） loom fly飞花织入

color thread end left inside，trapped color thread end 藏色线（撞色线头被车在衣服封闭部位内） broken yarn 断纱 thick yarn 粗纱 yarn drawn out 抽纱 knot 结头 slub 毛粒

looping 起耳仔 bubble 起泡 pilling 起球

broken hole 破洞

off grain 丝缕歪（布纹歪） streaky mark 起横 fabric defect 布疵 knit fault 织疵

major defect 大疵，严重疵点(大鸡） minor defect 小疵，轻微疵点(细鸡) thread end 线头 yarn end 毛头 fly up 飞起，翘起 right side 正面 wrong side 反面

wrong seam type 缝骨类型错

poor hand feel of product- not as specified 手感与确认样不符 X is 1”smaller than spec 某部位比尺寸表小1英寸 X is 1”above than spec 某部位比尺寸表大1英寸 The proportion of 60% 比例达60%

2、Stitching quality缝制

stitching quality is not good 缝制不良 stitch seam is uneven双轨接线

stitch seam leans out line 线路偏移

bad join stitching，poor repair stitching 接线不良(驳线不良) overlap stitching 接线(驳线)

poor back stitch 回针不良(返针差) poor linking 连接不良 broken stitch 断线

run off stitch （车缝）落坑 raw edge，raw-edge 散口

open seam，seam opening 开缝，裂缝(爆口) seam slippage 线缝松脱(爆口)

stitch not in seam shadow 露暗线 skipping stitch 跳线 skipping 跳针

drop needle 漏针，抽针，抽条，抽窿 needle hole 针洞，针孔

seam overturn 缝头方向错(止口反骨) pleated sewing 车缝打褶 pucker 起皱

seam puckering 线缝皱缩(骨位皱) seam twist 缝骨扭

seam wavy 缝骨起波浪(缝骨起蛇) sewn in waste 车缝时混有杂物

needle damage （缝针导致的）面料损坏 stitch density uneven 线迹密度不均匀 stitch tension uneven 线迹张力不均匀

3、Collar 领

Uneven collar 歪领

collar deviates from front center line 倘领偏斜 creases below neckline 领窝不平

bunches below back neckline 后领窝起涌 wrinkles at top collar 领面松 top collar appears tight 领面紧 crumples at top collar 领面起泡

collar band is longer than collar 底领伸出 collar band is shorter than collar 底领缩进

wrinkles at collar band facing内领座起皱(内下级领起皱) collar band lean out of collar 底领外露 collar edge appears loose领外口松 collar edge appears tight 领外口紧

collar points high/low 领尖高低，领尖不对称（不在同一水平线）

overlap collar 叠领 tight neckline 领卡脖

collar stand away from neck 领离脖 wrinkles at top lapel 驳头起皱 top lapel appears tight 驳头反翘 lapel edge appears loose 驳头外口松 lapel edge appears tight 驳头外口紧 lapel roll line is uneven 驳口不直 gorge line is uneven 串口不直

Broken collar / cuff and hem 烂領 Looping at neckline 领圈起耳仔

4、Shoulder 小肩

puckers at shoulders 小肩起皱 wrinkles at shoulder 塌肩 shoulder pucker 肩缝皱

5、Armhole 袖隆

armhole pucker 袖窿起皱，夹圈起皱 puckers at underarm seam 袖隆缝起皱

diagonal wrinkles at sleeve cap 绱袖不圆顺

6、Sleeve 袖子

sleeve leans to front 袖子偏前 sleeve leans to back 袖子偏后 inseam leans to front 前袖缝外翻

diagonal wrinkles at sleeve lining 袖里拧

inner cuff visible/exposed 袖头止口反吐，袖头内层外露 wrinkles at sleeve opening 袖口起皱 cuff edge not level 袖口边不平齐

uneven length of sleeves 左右袖长不等，长短袖

7、Placket 门襟 grin 露齿，裂口

wrinkles at zip fly 拉链起皱 zipper not movable 拉链难以开合 zipper wavy 拉链起波浪，拉链起蛇 placket wavy 前筒起蛇（皱） neck drop pucker 门襟顶部起皱

placket bottom spread open 门襟豁(筒脚张开)

facing leans out from front edge 前襟止口反吐（里料外露） bump at placket edge 门襟边扣眼位凸起(筒边钮门位不顺直) placket wavy 门襟起波浪（不平伏） creases at right fly 里襟里起皱

under placket exposed 里襟外露、底筒外露 uneven length of plackets 里外襟长短

fabric too close to zipper 面布车得太贴近拉链 lining too full/tight 里布太多/太紧

horizontal seams not level 水平缝骨（左右）没对齐 hem not level 下摆边不平齐 wrinkles at hem 底边起皱

8、Pockets 口袋

slanting pocket 歪袋

uneven lips （袋口）嵌线宽不均匀（大小唇） overlap lips 叠唇

pockets high/low （左右）口袋不对称（高低袋） flap lining leans out of edge 袋盖反吐 flap edge is uneven 袋盖不直 pocket flap stick up 袋盖反翘

creases on two ends of pocket mouth 袋口角起皱 split at pocket mouth 袋口裂 smiling pocket 袋口豁，（口袋）笑口

underply exposed，underply turn out 止口反吐，里层外露 Rock / sand inside pockets 袋內有石

9、Rides up起吊

back of coat rides up 后身起吊

center back ride up，center back seam pulling 后中起吊 hiking up 起吊

hiking at bottom of placket 前筒吊脚 outseam/inseam pulling （侧缝/内缝）吊脚 split hem line rides up 裙身吊

10、Pants 裤子

wrinkles at waistband facing 腰缝起皱 bunches below waistline seam 腰缝下口涌

support stitch visible 辅助线外露，定位线外露 end of waistband is uneven 腰头探出 crotch cross unmatch 裤裆十字骨错位 wrinkles at front rise 前浪不平 slack seat 后裆下垂 tight crotch 夹裆 short seat 短裆

bursting of crotch seam 裆缝断线 twist leg 扭髀扭脚

two legs are uneven 裤脚前后 leg opening is uneven 脚口不齐

11、Skirt 裙子

split at lower part of skirt裙裥豁开 skirt flare is uneven 裙浪不匀

12、Vent 衩

lack of fullness at chest 塌胸

dart point crumple 省尖起泡，省尖起皱 back vent unmeet 背衩豁（张开）

crossed back vent 背衩搅（重叠太多） crossing at back vent 背衩搭叠过多

13、Printing 印花

printing scrimp 印花起裂

wrong color combo 颜色组合错误 wrong pattern 图案错误

uneven color 深浅色，颜色不均匀 uneven dying 染色不均匀

color too dull/bright 颜色太哑/闪 total different color 颜色完全不同 color fading 褪色、甩色 stripy 色挡，色花 marking off 搭色

color shade, off shade, color deviation 色差

color shading within one garment （同件衣服内）裁片色差 shading garment to garment 衫与衫之间色差

embroidery design out line is uncovered 绣花不良

14、Stripes 条格

stripes not match 对条不良 checks not match 对格不良 uneven plaids 格仔不均匀

mismatched stripe/plaid,side seam1/8”-1/4” 对格对条不佳，侧缝处偏差1/8-1/4

15、Front edge止口

front edge is uneven 止口不直

front edge is out of square 止口缩角 front edge is upturned 止口反翘

facing leans out of front edge 止口反吐 split at front edge 止口豁

crossing at front edge 止口下部搭叠过多

16、Puckers 行棉

puckers at quilting 绗棉起皱

padded cotton is uneven 絮棉不均 empty hem 边缘缺棉

17、Washing 洗水

Uneven washing effect 洗水效果不均 Different washing effect 洗水效果不同 washing quality is not good 洗水不良 washing streak 洗水痕 Streaky mark 洗水条纹痕 Crease mark 洗水摺痕

overwash 洗水过度，洗水太重

Pilly / hairy on garment surface 洗水后表面有毛粒或起毛 Sandy on garment surface 衣服表面有沙的感觉

Mildew or heavily odor garment. 霉味或很重的味在衣服上

18、Pressing 整烫

poor ironing 烫工不良 underpress 熨烫不够

overpress 熨烫过度、烫过火 iron-shine 极光 Melt 熔化

Glazing / shinny pressed 起鏡 Sheer / glossy 起鏡面

glaze mark （熨烫）起镜，起极光 Crease mark 摺痕印 Burn mark 燒焦印

pressing mark 烫痕，压痕 Pleated press 熨褶痕

seam gapping藏木虱，藏止口（烫工） Color stain 顏色斑点 Wet 潮湿

crease line leans to outside 烫迹线外撇 crease line leans to inside 烫迹线内撇

Seam not fully pressed open 骨位沒有完全熨开

Zip / button mark made by improper pressing 熨工欠佳致有拉链痕纽痕 Elastic is not pre-shrinkage before setting 橡筋未烫縮水 Poor pressing / fusing of interlining 烫籿压籿效果不佳

19、Trims 辅料

Production status 生产情况

Missing price ticket / hangtag / label 欠价钱牌

Wrong placement of price ticket / hangtag / label 价钱牌、挂牌、唛头位置错误

Wrong size / color in assortment 尺碼 顏色分配错误 Carton/casepack assortment incorrect 包装搭配不正确 wrong size indicated 错码 off size 尺寸不合

Improper folding 摺法不正确 Dirty polybag 胶带污渍

Broken export carton 外箱烂 Carton over weight 外箱過重

Incorrect carton size 外箱尺寸不合規格